Land Rover Discovery 4 Auto Box Oil Change

Unfortunately a lot of drivers dont know when they need to change the oil or what happens if they dont do it regularly. You should get a good flow of oil.

Land Rover Discovery 4 Lr4 Wsm 2010 2012 Manual De Servico Youtube

After some requests to split the thread - this new thread is where I will.

Land rover discovery 4 auto box oil change. Tim Krieger of Jaguar Land Rover says. The Land Rover Discover and Ranger Rover Sport are well known for automatic gearbox problems starting from around 80000 miles some of the common faults are shuddering at approx 2000rpm slow gear engagement and gear changes when cold torque converter lock up to name just a few and the cost that some customers are being quoted runs into thousands of pounds so people are selling their. The existing D 34 Automatic Transmission FAQ was created in the days of 6 speed transmissions in all.

If not the pump has been broken during installation and will need replacingrebuilding. Disco 4 Automatic Transmission FAQ - 8 Speed. The first service to be completed on a 2010 Discovery transmission would depend on the engine and transmission fitted to the vehicle.

Land Rovers recommended interval of 12K-15K oil changes on late model Rovers with synthetic engine oil is an often-discussed topic in the forum community. EP 90 EP 80w90 EPX 80W90. The Land Rover Discovery 4 8 speed gearbox oil change is very important mainly due to the constant friction of the clutch plates with the automatic gearboxs there is a good amount of heat generated.

The real problem was at next tranny oil filter change where I would have to preorder the oil filter from Germany not stocked in Canada at a cost of maybe near 200. Run the transmission through all gears. If you can change the gearbox oil frequently this can help dispel the heat more efficiently.

Replace the oil fillercheck plug. You wont be able to just stick them in you. Once the draining has finished using the new washer close up the sump plug and commence refilling the box via the level plug.

R380 gearbox oil. Check the fluid as follows. This is a filter and fluid kit for all vehicles using the ZF 8HP70 automatic transmission - Discovery 4 Range Rover.

The first thing to do is to remove the oil cooler pipe from the bottom of the gearbox put a container under the open end to catch the oil and start the engine. Recheck level making sure it just runs out of the hole. Remove gearbox sump inspect oil and any contaminants in the sump and replace the gearbox oil filter and sump Fill the gearbox with the manufacturers recommended specification of transmission oil Flush the gearbox until all the oil has been replaced this typically means that we use about 15-20 litres of oil instead of the maximum of 9 litres that fills the gearbox from scratch.

Land Rover Discovery 4s engine consists of dozens of moving. In this video we drain the oil and remove the sump on our Land Rover Discovery 4 30 TDV6 automatic gearbox ready for a filter change. Start the engine and allow idle to stabilize.

Details of that here. ZF recommends oil and filter changes after 50000 to 75000 miles on all 5 6 8 speed automatic gearboxes to ensure optimum performance. The sump and filter are normally one piece and fitting involves jacking the engine up and unbolting the mounts plus.

First off get the car parked on a level surface then the first job is to drain the oil from the gearbox sump below is the sump and the drain plug at the bottom. Capacity 27 l from dry on Discovery 1 no gearbox oil cooler practically 24-25 when changing LT230 transfer box oil. Land Rover Discovery 4 2016 Oil Change.

The factory service information says the manual gearbox oil should be renewed every 10 years and the advice is 240000km for oil and filter on autos. I had figured that maybe a metal pan and filter from a Ford F250 5 speed ZF would work but no I pretty much have to use the official ZF part number from Germany as there is no AB aftermarket pan easily available here. Tranfer box is 152l of special transfer box oil from dealers about 16l Auto box fluid can be got from 4-tech ISTR will supply the proper Shell stuff might be in a generic bottle though as he buys the big barrels You can get the millermatic stuff but ISTR that its not the fill for lifetime quality so would need changing more regularly.

ZF recommend oil and filter changes after 50000 to 75000 miles on 8 speed automatic gearboxes to ensure optimum performance. Degradation in oil can lead to judder noise and a deterioration in gear change quality. Many are saying and We agree that the frequency of changes should be half that every 7500 miles or you risk causing long-term wear and damage to the engine.

At this stage you will only be able to get perhaps 2ltrs of oil in the box. If you have not removed the oil fillerlevel plug remove it and fill until it just runs out of the hole. From the factory a fluid and filter change on this transmission is a very lengthy process.

As long as you choose a high quality oil that meets the specifications above then all will be ok. So with this in mind I looked else where to see what was around. Changing the oil and examining the Land Rover Discovery 4 2016 oil fiter is the most important maintenance service.

My Local Land Rover Dealer no longer supplies the differential transfer box oils in 1 litre bottles as they use it from a large barrel in their workshop. Through the life of that thread things have got more complicated with the introduction of the 8HP70 8 speed in late 2012. Capacity 23 from dry practically 2-21 when changing Its relatively easy to reach and remove the breathers on both boxes.

For a standard oil filter change you will need a new filter o rings at least 5 litres of ATF oil and a new sump gasket.

Discovery 4 Parts And Accessories John Craddock Ltd