Land Rover Discovery 2 Diff Oil Change

I went to the dealer today and picked up 2 quarts of oil for the transfer case 2 quarts of oil for the rear diff with locker and 2 quarts for the front locker. Dingocroft stocks Penrite Oils Comma Oils and Land Rover branded oils where available.

Pin On Land Rover

You need EP8090 gear oil EP stands for Extreme Pressure it has to put up with the diff gears rotating and meshing together at speed so its the same stuff thats used in the Land Rover transfer box.

Land rover discovery 2 diff oil change. 10w40 semi-synthetic 500 Discovery 2 - 4046 V8 petrol with oil cooler. It worked for me especially when the bottle does not fit. Engine oil and filter change.

This includes the front and rear axle or Differential oils. Page 1 of 2 1 2 Last. I have full specifications on SAF-XO if you would like to get hold of it.

Use Shock Oil 1 or Shock Oil 2 for fast road and competition use. Allow oil to drain. Our mission is to support all original Land Rover models no longer supported by your local Land Rover franchise.

Manual gearbox with oil cooler. It again is a drain and fill to overflow to ensure the level is correct. Results 1 to 20 of 34.

Start pumping and look to see the oil going up into the differential. Freaking hilariousI think I did a double take when the cashier told me. Replaced them last week after 40k still the same color as new.

Discovery 3 Diff oil change. Apply Loctite 290 to threads of oil drain plug. Fill transfer box with recommended oil to bottom of oil fillerlevel plug hole.

23 litres Fill from dry. Manual gearbox without oil cooler. The prop shaft can now be bolted to the replacement rubber doughnut.

Castrol SAF-XO is very expensive. 200I kid you not. The oil in the differentials has to work very hard even during normal use if you go off road and in particular wading in deep muddy water changing or at least checking your diff oils is very important.

Fit the bolt with a bit of loctite and tighten it very tight Same procedure as for loosening. Fill in the oil into the bottle. Apply liquid gasket to the diff flange then offer it up to the axle casing and bolt in make sure you have a good seal all the way round or it will leak.

58 litres Engine oil refill from dry. Normally this vents through an axle breather pipe that extends up to the chassis but if it is blocked then the pressure will force the oil out of the nearest seal. Oil Change on 2004 Disco 2 My 2004 Disco 2 will reach the mark of 90000 miles.

Apply liquid gasket again to the half shaft flange then slide into the hub and axle case. First thing is to make sure you have the new oil for topping up the diff. Engine - V8 without oil cooler.

This heats up the air inside the axle casing making it expand. I also use Mobil 1 75W-90 for the transfer case fr diffs. Replacing a diff pinion oil seal on Rover axles.

The Workshop Manual from Land Rover prescribes a GL-5 oil with viscosity 90. The difference between the two types is that the rover type diff has the pinion bearing preload set by shims whereas the salisbury axle has the pinion bearings preload set by a crushable spacer. Remove oil drain plug.

Connect a footor low pressure air compressor air pump to the air valve. I also recommend that Castrol SAF-XO be used. Teddygoat Guest I would rather eat rotten sardines than buy anything from the dealers.

10w40 diesel semi-synthetic 720 Discovery 2 - 4046 V8 petrol without oil cooler 1998-2004 RX1896. Differential Transfer Case And Axle Service Kit For Land Rover Discovery Series 2 Front And Rear Includes 6 Quarts Genuine Differential Oil 75W90R GL5 And Replacement Plugs And Washers. After changing the differential Oils a few weeks ago it was time to also do the Transfer Box as well.

I found a propshaft tool wasnt that easier than 2. Land Rover Discovery 3 TDV6 2007. What this means is that providing you have no play you can change the rover pinion seal without worrying about upsetting the pinion bearing preload.

Watch Doug our Land Rover Master Technician perform the differential transfer case and axle oil service using complete Kit DTCM600C on a 1999-2004 Discovery Series 2. Remove all traces of sealant from threads of oil. Castrol recommends that Castrol SAF-XO be used in the differentials.

They have left a worse taste in my mouth. 20140714 1230 PM 7. Clear hose in the upper filling hole.

Anyone care to guess how much it cost. Then remove the propshaft by undoing the 4 bolts holding it to the diff output flange. The transfer box takes the same spec of oil as the front and rear axles but just has a slightly larger capacity.

Fit transfer box drain plug and tighten to 30 Nm 22 lbfft. In this video Doug will show you the drain and fill points of the front and rear differential and transfer case and axles. As the Land Rover is a 4x4 it has a lot more oils that have to be changed when compared to a standard vehicle.

Discovery 2 - 25 Td5 1998-2004 RX1890. CAPACITIES FLUIDS AND LUBRICANTS Lubrication. Oil the diff flange inner seal and push it on gently - rotate it a bit as it goes on jack up a wheel to do this to make sure it does not grab and bend the lip.

Discovery 2 1998 to 2004 Discovery 3 2005 onwards Freelander 1 1998 to 2007. Engine oil and filter change. When the vehicle is moving the differential creates an enormous amount of heat.

627 litres Engine oil refill from dry. First take out the fill plug for your axle just to check it will come out then take out the drain axle and let the oil drain into a suitable container.

Reviews Of The Owners Of Land Rover Discovery Ii Land Rover Discovery Ii Td5 Uncommon Person Discovery Motors 2